ARB OME application catalogue

Contents!A1 17. No top mounting bushes supplied use OME3133 / OME3134 / OME3135, vehicle specific refer to vehicle selection page. OE bushes may be re-used if in good condition. 18. 60130 and 60131 cannot be used as a shock only OE replacement on Colorado 7/Trailblazer Models. Can be used as an OE replacement for Isuzu MU-X. 19. No top mounting bushes supplied use OME3121. OE bushes may be re-used if in good condition. No dirt shield supplied, please re-use OE. 20. Shock absorber 60140 is suited for constant rear loading in excess of 800kgs. 21. 1975 and newer FJ40's may need to use N76 shocks in rear: Pre 1975 shock eye in the top of the axle housing use N89/N95 12 /60032/60064. Post 1975 lower shock eye is below leaf spring use N76 with OMEB11 Bush Kit. 22. FK29 Rear Driveshaft Spacer is a mandatory fitment. 23. Top mount bump stop and bushes not supplied, re-use OE items. 24. For trimming purposes only, maximum 1 packer per strut. 25. OME665 Lower Shock Mount Stone Guard is mandatory fitment to rear shocks to protect against severe stone peppering encountered on loose road surfaces. 26. FK22 Front Shock Absorber Upper Mount Support Bracket Kit is a mandatory fitment. 27. When fitting 60018 / 60070 it is mandatory to fit longer coils 3062 - 3066 for springs to remain trapped with shocks fully extended, fit FK62 to prevent shock damage, fit FK63 for front driveshaft clearance and rear extended travel, fit FK64 which replaces OE upper shock mount when fitting rear shocks and remove any inner helper coils already fitted. Caution: Front driveshaft MUST be replaced / modified with Double Cardan Joints and checked for Uni bind with OME shocks installed at droop. 28. Caution: Due to altered gearbox mounts on models after 1998 any lift above OE ride height may cause front driveline vibration that can only be rectified by fitment of front Double Cardan Joints. 29. Caster Kit will increase caster angle by 2 o . Check manufacturer's specifications to determine if Caster Kit is required. CALR1 suits 38mm wide control arms. CALR2 suits 44mm wide control arms. 30. Volkswagen Service Manual quotes that driveshaft bolts are a one use only. It is recommended to replace bolts. Replacement bolts Volkswagen Part Number N90991102 are to be sourced separately. 31. Suits 75mm and 100mm coils 32. Vehicle specific, refer to vehicle selection page for full details and to review important notification regarding modifications for off road use only along with warranty implications. JK Wrang ler: refer page 36 Patrol GU Y61 & GQ Y 60: refer page 75 LandCruiser 80 & 105 Seri es: refer page 96 33. For high articulation vehicles it is recommended to replace rear upper shock mount with FK64 and matching shock absorbers 60146 or 60147 34. Fitment of FK92 and FK93 are mandatory . 35. Fitment of LCAJLFR Front Lower Control Arm is required to restore wheel alignment castor settings. 36. To ensure correct 90012 and 90013 strut fitment please refer to fitting instruction part number 3787896 Amarok Strut Fitting Guide. 37. For front fitment reuse OE Top hat and Mounting Bushes. For rear fitment UBolts, Rear Spring Bush Kits and Leaf Spring Bolt Fitting Kit are additional requirements. Extra Leaf, Trim Packer and Centre Bolt are optional. Refer to the vehicle selection page for full details. 38 Headlight Sensor Fitting Kit FK97 is required when fitting all OME extended travel rear shock absorbers. 170mm long 210mm long 250mm long 290mm long Note: The last 3 numbers of the part number indicates the length of the dirt shield. Front Open (mm) Closed (mm) Rear Open (mm) Closed (mm) Jeep JK 60066L 693 404 60067L 706 422 60066M 646 382 n/a n/a n/a 60052L 678 392 60053L 622 366 60047L 678 392 60049L 622 366 60013L 555 322 60015L 716 426 60070L 667 381 60071L 673 387 60018L 667 381 60020L 673 387 60037L 593 349 60039L 600 366 60024L 627 388 60025L 627 388 60037L 593 349 60039L 600 366 Cont. NITROCHARGER SPORT SELECTION Sports Dirt Shield - Strut NOTES: - (cont.) - *first part number has firmer valving. LandCruiser 80, 100 Vehicle Jeep XJ Jeep TJ Patrol Y60, Y61 Hard Sport Dirt Shield 384006250 Hard Sport Dirt Shield (Middle Front) NITROCHARGER SPORT L SERIES 384006210 Hard Sport Dirt Shield Hard Sport Dirt Shield 384006170 384006290 141-032-028 OME412422 PART NUMBER Nitrocharger Dust Boot - Black OME512422 Discovery I to 99 Range Rover to 5/95 60037L 593 60039L 349 366 Non Airbag Models Discovery II to 04 Defender 90, 110, 130 600 141-032-027 Sports Dust Boot - Black Nitrocharger Dust Boot - Yellow REPLACEMENT NITROCHARGER SPORT DIRT SHIELDS OME struts can only be installed with OME coils. Page 13 OME INT CAT. NO.43 APRIL 2020